Subaru Legacy/Outback

1999-2003 of release

Repair and operation of the car



Subaru of Legasi, Autbek
+ Cars Subaru Legacy, Outback
+ Operation manual
+ Routine maintenance
+ Engine
+ Cooling systems, heating
- Power supply system and release
   Specifications
   + System of injection of fuel
   + Control systems of the engine and decrease in toxicity of the fulfilled gases
   + System of production of the fulfilled gases
+ Electric equipment of the engine
+ Manual box and differential
+ Automatic transmission
+ Coupling
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment




d9f1bda0



Specifications

General parameters

 

Fuel type

Unleaded gasoline is not worse than AI95

Turns of idling, rpm

L models 2.0 and 2.5

700 ± 100

Models of 3.0 l

600 ± 100

Power supply system

Type

Fuel tank

Location

Under a back seat

Volume, l

64

Fuel pump

Type

The rotor

Pressure of a cut-off, kPa (kgf/cm2)

370 ÷ 667 (3.77 ÷ 6.9)

Expense (at supply voltage of 12 V and a pressure of 300 kPas), l/h

L models 2.0 and 2.5

Not less than 65

Models of 3.0 l

2001 vyp.

Not less than 65

2002 vyp.

Not less than 85

Fuel filter

Type

Cartridge (with a replaceable cartridge)

Gas pedal

Side play size (on a block), mm

1 ÷ 4

Full length of the course (on a block), mm

50 ÷ 55

The course length leading to activation of the kickdown mode, mm

48 ± 1

The limit admissible size of a lateral side play (on a block), mm

5.0

Limit admissible value of size of a vystupaniye of the wrung-out plunger of the sensor switch of activation of the kickdown mode, mm

2 / 0

Control system of the engine

Codes of malfunctions (DTC)

Models with OBD II (H4 and H6) *

Code

The most probable source of violation

P0031

 

Short circuit on the case in a chain of the heater dokatalitichesky a lambda probe (H4)
Short circuit on the case in a chain of the heater dokatalitichesky a lambda probe of the right number of cylinders (H6)

P0032

 

Short circuit on + in a chain of the heater dokatalitichesky a lambda probe (H4)
Short circuit on + in a chain of the heater dokatalitichesky a lambda probe of the right number of cylinders (H6)

P0037

Refusal in a chain (short circuit on the case) post-catalytic a lambda probe

P0038

Short circuit on + in a chain of the heater post-catalytic a lambda probe

P0051

Short circuit on the case in a chain of the heater dokatalitichesky a lambda probe of the left number of cylinders (H6)

P0052

Short circuit on the case in a chain of the heater dokatalitichesky a lambda probe of the left number of cylinders (H6)

P0066

Short circuit on the case in a chain e/m the valve of an injector of admixture of air (H4)

P0067

Short circuit on + in a chain e/m the valve of an injector of admixture of air (H4)

P0106

Refusal in pressure sensor chain in the inlet pipeline (MAP)

P0107

Short circuit on the case in a MAP sensor chain

P0108

Short circuit on + in a MAP sensor chain

P0111

Refusal in a chain of the sensor of temperature of the soaked-up air (IAT)

P0112

Short circuit on the case in an IAT sensor chain

P0113

Short circuit on + in an IAT sensor chain

P0117

Short circuit on the case in a chain of the sensor of temperature of cooling liquid (ECT)

P0118

Short circuit on + in an ECT sensor chain

P0021

Refusal in a chain of the sensor of provision of a butterfly valve (TPS)

P0122

Short circuit on the case in TPS chain

P0123

Short circuit on + in TPS chain

P0125

Temperature of cooling liquid is insufficient for correct functioning of feedback in a chain of management of fuel supply

P0130

Refusal in a chain dokatalitichesky a lambda probe (reimpoverishment of air and fuel mix) (H4)

P0131

 

Break in a chain dokatalitichesky a lambda probe (H4)
Break in a chain dokatalitichesky a lambda probe of the right number of cylinders (H6)

P0132

 

Short circuit in a chain dokatalitichesky a lambda probe (H4)
Short circuit dokatalitichesky lambda probe of the right number of cylinders (H6)

P0133

 

The slowed-down reaction dokatalitichesky a lambda probe (H4)
The slowed-down reaction dokatalitichesky a lambda probe of the right number of cylinders (H6)

P0136

Refusal in a chain post-catalytic a lambda probe (H4)

P0137

Short circuit on the case in a chain post-catalytic a lambda probe (H6)

P0138

Short circuit on + in a chain post-catalytic a lambda probe (H6)

P0139

The slowed-down reaction post-catalytic a lambda probe

P0151

Break in a chain post-catalytic a lambda probe of the left number of cylinders (H6)

P1052

Short circuit post-catalytic lambda probe of the left number of cylinders (H6)

P0153

 

The key of an immobilizer (H4) is incorrect
The slowed-down reaction dokatalitichesky a lambda probe of the left number of cylinders (H6)

P0170

Reimpoverishment / pereobogashcheniye air and fuel mix (H4)

P0171

Reimpoverishment of mix on a signal dokatalitichesky a lambda probe of the right number of cylinders (H6)

P0172

Reenrichment of mix on a signal dokatalitichesky a lambda probe of the right number of cylinders (H6)

P0174

Reimpoverishment of mix on a signal dokatalitichesky a lambda probe of the left number of cylinders (H6)

P0175

Reenrichment of mix on a signal dokatalitichesky a lambda probe of the left number of cylinders (H6)

R0301-R0306

The admission of ignition in the cylinder No. 1 ÷ No. 4 (H4) of/№1 ÷ No. 6 (H6), respectively

P0327

 

Short circuit on the case in a chain of the sensor of a detonation (KS) (H4)
Short circuit on the case in a chain of KS 1 (H6)

P0328

 

Short circuit on + in a chain of KS (H4)
Short circuit on the case in a chain of KS 1 (H6)

P0332

Short circuit on the case in a chain of KS 2 (H6)

P0333

Short circuit on + in a chain of KS 2 (H6)

P0335

Refusal in a chain of the sensor of provision of a cranked shaft (CKP)

P0336

Refusal in a CKP sensor chain

P0340

Refusal in a chain of the sensor of provision of a camshaft (CMP)

P0341

Refusal in a CMP sensor chain

P0400

Refusal of system of recirculation of the fulfilled gases (EGR) (H6)

P0420

Inadmissible decrease in efficiency of the catalytic converter

P0444

Short circuit on the case in a chain of the operating valve of a purge of a coal adsorber of EVAP (H4)

P0445

Short circuit on + in a chain of the operating valve of a purge of a coal adsorber of EVAP (H4)

P0458

Short circuit on the case in a chain of the operating valve of a purge of a coal adsorber of EVAP (H6)

P0459

Short circuit on + in a chain of the operating valve of a purge of a coal adsorber of EVAP (H6)

P0461

Violation of serviceability of functioning of the sensor of a reserve of fuel

P0462

Short circuit on the case in a fuel reserve sensor chain

P0463

Short circuit on + in a fuel reserve sensor chain

P0464

Violation of stability of an entrance signal of the sensor of a reserve of fuel (H4)

P0480

Refusal in a chain of the relay of 1 fan of the cooling system (H4)

P0483

Refusal of functioning of the fan of the cooling system

P0500

Failure of the sensor of speed of the movement of the car (VSS)

P0506

Unforeseen decrease in frequency of rotation of a cranked shaft at operation of system of stabilization of turns of idling (IAC)

P0507

Unforeseen increase of frequency of rotation of a cranked shaft at operation of IAC

P0508

Short circuit on the case in a chain of system of stabilization of turns of idling (IAC)

P0509

Short circuit on + in IAC chain

P0512

Short circuit on + in a starter switch chain

P0513

The key of an immobilizer (H6) is incorrect

P0562

Short circuit on the case in a chain of system of a charge (H4)

P0563

Short circuit on + in a chain of system of a charge (H4)

P0604

Error of checksum of memory of the internal module of management

P0661

Short circuit on the case in a chain of the operating solenoid of the induction valve (H6)

P0662

Short circuit on + in a chain of the operating solenoid of the induction valve (H6)

P0691

Short circuit on the case in a chain of the relay of 1 fan of the cooling system (H6)

P0692

Short circuit on + in a chain of the relay of 1 fan of the cooling system (H6)

P0703

Refusal in a braking sensor switch chain

P0705

Refusal in a situation AT sensor switch chain

P0710

Refusal in ATF temperature sensor chain

P0715

Refusal in a chain of the sensor of turns of the turbine of the AT hydrotransformer

P0720

Malfunction in a chain of VSS No. 2 (H4)/forward (H6)

P0725

Failures in giving of a signal of turns of the engine

P0731-P0734

Failures in giving of a signal of inclusion of the 1st yo 4th transfer, respectively

P0741

Violation of serviceability of functioning of the coupling of blocking of the hydrotransformer

P0743

Electric refusal in a chain of the coupling of blocking of the hydrotransformer (executive e/m the blocking valve)

P0748

Electric refusal in a chain e/m the valve of management of pressure in the line

P0753

Electric refusal in a chain e/m the valve of switching 1

P0758

Electric refusal in a chain e/m the valve of switching 2

P0778

Refusal in a chain e/m the valve of management with a brake pressure of 2-4

P0785

Refusal in a chain e/m the valve of management of distribution of a brake 2-4

P0851

Short circuit on the case in a chain of the sensor switch of permission of start (H6)

P0852

Short circuit on + in a chain of the sensor switch of permission of start (H6)

P086

Refusal in a chain of an entrance signal of diagnostics of AT (H6)

P0865

Short circuit on the case in a chain of an entrance signal of diagnostics of AT (H6)

P0866

Short circuit on + in a chain of an entrance signal of diagnostics of AT (H6)

P1110

Short circuit on the case in a chain of the sensor of atmospheric pressure

P1111

Short circuit on + in a chain of the sensor of atmospheric pressure

P1112

Refusal in a chain of the sensor of atmospheric pressure

P1134

Failure of the microprocessor dokatalitichesky lambda probe (H6)

P1137

Refusal in a chain dokatalitichesky a lambda probe (H4)

P1139

Refusal in a chain of the heater dokatalitichesky a lambda probe of the right number of cylinders (H6)

P1140

Refusal in a chain of the heater dokatalitichesky a lambda probe of the left number of cylinders (H6)

P1142

Short circuit on the case in TPS chain

P1146

Short circuit on + in pressure sensor chain

P1152

Short circuit on the case in a chain dokatalitichesky a lambda probe of the right number of cylinders (H6)

P1153

Short circuit on + in a chain dokatalitichesky a lambda probe of the right number of cylinders (H6)

P1154

Short circuit on the case in a chain dokatalitichesky a lambda probe of the left number of cylinders (H6)

P1155

Short circuit on + in a chain dokatalitichesky a lambda probe of the left number of cylinders (H6)

P1442

Refusal in a chain of the sensor of a reserve of fuel 2 (H4)

P1480

Short circuit on + in a chain of the relay of 1 fan of the cooling system (H4)

P1507

Violation of serviceability of functioning of system of stabilization of turns of idling (transition to emergency operation)

P1510

Short circuit on the case in an alarm chain e/m the IAC 1 valve (H4)

P1511

Short circuit on + in an alarm chain 1 e/m the IAC (H4) valve

P1512

Short circuit on the case in an alarm chain 2 e/m the IAC (H4) valve

P1513

Short circuit on + in an alarm chain 2 e/m the IAC (H4) valve

P1514

Short circuit on the case in an alarm chain 3 e/m the IAC (H4) valve

P1515

Short circuit on + in an alarm chain 3 e/m the IAC (H4) valve

P1516

Short circuit on the case in an alarm chain 4 e/m the IAC (H4) valve

P1517

Short circuit on + in an alarm chain e/m 4 IAC (H4) valves

P1518

Short circuit on the case in a starter switch chain

P1540

Refusal in a chain of VSS 2 (H4)

P1560

Refusal in a feedback tension chain

P1570

Immobilizer antenna

P1571

Discrepancy of a basic code of an immobilizer (IMM) and ECM

P1572

Refusal in a chain of an immobilizer (IMM) (except an antenna contour)

P1574

Refusal of an identification of an identification code of a key immobilizer

P1576

Refusal of re-recorded ROM (EEPROM) of ECM

P1577

Refusal of EEPROM IMM

P1590

Short circuit on + in a chain of the sensor switch of permission of start (H4, model with AT)

P1591

Short circuit on the case in a chain of the sensor switch of permission of start (H4, model with AT)

P1592

Refusal in a chain of the sensor switch of neutral provision of transmission (H4, model with RKPP)

P1594

Refusal in a chain of an entrance signal of diagnostics of AT (H4)

P1595

Short circuit on the case in a chain of an entrance signal of diagnostics of AT (H4)

P1596

Short circuit on + in a chain of an entrance signal of diagnostics of AT (H4)

P1698

Short circuit on the case in a chain of a signal of shutdown of management of an engine torque

P1699

Short circuit on + in a chain of a signal of shutdown of management of an engine torque

P1700

Refusal in TPS chain for AT

P1701

Refusal in a chain of a signal of installation of a tempostat for AT

P1703

Refusal in a chain of the distributive electromagnetic valve of coupling of the lowering transfers of AT

P1711

Refusal in a chain of a signal of shutdown of management of 1 torque of the engine

P1712

Refusal in a chain of a signal of shutdown of management 2 of an engine torque

* H4 = 4-cylinder engines, H6 = 6-cylinder engines

Models with OBD Subaru (H4)

Code

The most probable source of violation

11

Lack of a signal of CKP at inclusion of a starter; break or short circuit in an electrical wiring on a chain site between ECM and the CKP sensor

12

Violation of parameters of a signal of the switch of a starter; break or short circuit in an electrical wiring on a chain site between ECM and the switch

13

Lack of a signal of CMP at correct receipt of a signal of CKP; break or short circuit in an electrical wiring on a chain site between ECM and the CMP sensor

21

Violation of parameters of a signal of the ECT sensor; break or short circuit in an electrical wiring on a chain site between ECM and the ECT sensor

22

Violation of parameters of a signal of the sensor of a detonation; break or short circuit in an electrical wiring on a chain site between ECM and KS

23

Malfunction in a chain of the measuring instrument of mass of the soaked-up air (MAF)

24

Functioning refusal e/m IAC valve; break or short circuit in an electrical wiring on a chain site between ECM and e/m the valve

26

Violation of parameters of a signal of the IAT sensor; break or short circuit in an electrical wiring on a chain site between ECM and the IAT sensor

31

Violation of parameters of a signal of TPS; break or short circuit in an electrical wiring on a chain site between ECM and TPS

32

Functioning refusal lambda probe; break or short circuit in an electrical wiring on a chain site between ECM and a lambda probe

33

Violation of parameters of a signal of VSS; break or short circuit in an electrical wiring on a chain site between ECM and VSS

35

Refusal e/m valve of management of an adsorber purge; break or short circuit in an electrical wiring on a chain site between ECM and e/m the valve of management of a purge

38

Violation of parameters of the developed TCM of a signal of management of a torque; break or short circuit in an electrical wiring on a chain site between ECM and TCM

45

Violation of parameters of a signal of the sensor of pressure; break or short circuit in an electrical wiring on a chain site between ECM and the sensor

46

Violation of parameters of a signal of the SO resistor; break or short circuit in an electrical wiring on a chain site between ECM and the resistor; violation of adjusting parameters of the SO valve

49

Malfunction in a chain of the SO adjusting resistor

51

Violation of parameters of a signal of the sensor switch of neutral provision of transmission (model with RKPP) / permissions of start (model with AT); break or short circuit in an electrical wiring on a chain site between ECM and the sensor

53 *

Refusal of system of an immobilization of the engine

85

Violation of serviceability of functioning of system of a charge

* Only for the models equipped with an immobilizer

Efforts of a tightening of threaded connections, Nanometer

 Efforts of a tightening of threaded connections are given also in the text of the Head and on sopr. illustrations.

Drain stopper of the main chamber of a fuel tank

26

Bolts of assembly tapes of fastening of a fuel tank

33

Bolts of fastening of panels of protection of a fuel tank

18

Nuts of fastening of assembly of the fuel level sensor in an additional chamber of a tank

4.4

Bolts of a fixing flange of the fuel pump

5.9

Nuts of a fixing flange of the valve of a cut-off of fuel

4.4

Bolts of fastening of a thermoprotective cover

33

Bolts of basic arms of a tube of a jellied mouth of a fuel tank

7.4

Elements of fixture of a coal adsorber of EVAP

L models 2.0 and 2.5

From OBD II (nut)

23

About OBD Subaru (bolts)

7.4 ± 2.0

Models

3.0 l

Bolts

33

Nuts

23

Fastening bolt e/m valve of management of an adsorber purge

L models 2.0 and 2.5

16

Models of 3.0 l

19

Bolts of fastening of an air inlet

7.5

Bolts of fastening of the air cleaner

L models 2.0 and 2.5

6.5

Models of 3.0 l

32.4

Bolts of fastening of basic arms of the air cleaner (l models 2.0 and 2.5)

16

Fastening collar

Bolts/nut of fastening of a rezonatorny chamber of an inlet air path

L models 2.0 and 2.5

32.4

Models of 3.0 l

7.5

Nut of fastening of a connecting branch pipe of an inlet air duct (l models 2.0 and 2.5)

7.5

Elements of fixture of a basic arm of an inlet air duct (l models 2.0 and 2.5)

Nut

7.5

Bolt

14

Collars of fastening of connecting sections of an inlet air duct

3

L models 2.0 and 2.5

2.5

Models of 3.0 l

3

Collar of fastening of a sleeve of an air duct to an air cleaner cover

3

Bolts of fastening of an airreception chamber (model of 3.0 l)

6.4

Collar of fastening of a sleeve of an air duct to a chamber airreception (model of 3.0 l)

3

Nut of fastening of the sensor switch of activation of the kickdown mode

12

Bolts of fastening of an arm of a pedal of gas

18

Lock-nut of fastening of a tip of a cable of the drive of a butterfly valve to pedal assembly

12

Bolts of fastening of the case of a throttle

22

Bolts of fastening of the sensor of provision of a butterfly valve (TPS)

1.6

Fastening screws e/m valve of stabilization of turns of idling (IAC)

L models 2.0 and 2.5

1.6

Models of 3.0 l

2.8

Screws of fastening of the sensor of pressure in the inlet pipeline (MAP) (model of 3.0 l)

1.6

Bolts of basic arms of fuel lines

5.0

Bolts of fastening of a basic arm of an injector of admixture of air (l models 2.0 and 2.5 with OBD II)

5.0

Bolts of fastening of an injector of admixture of air (l models 2.0 and 2.5 with OBD II)

6.4

Bolts of fastening of the sensor of temperature of the soaked-up air (IAT)

L models 2.0 and 2.5

3.4

Models of 3.0 l

19

Bolts/nut of fastening of the inlet pipeline

25

Bolt of fastening of the valve of management of a purge

19

Caps and nipples of the inlet pipeline

17

PCV valve (l models 2.0 and 2.5)

25

Bolts of fastening of the induction valve (model of 3.0 l)

19

Bolt of fastening of the operating solenoid of the induction valve (model of 3.0 l)

19

Bolts of fastening of basic arms of candle wires (l models 2.0 and 2.5)

Left arm

19

Right arm

5.0

Bolts of fastening of protectors of fuel highways

19

Bolts of fastening of fuel highways

19

Bolts of fastening of a tube of EGR (model of 3.0 l)

6.4

Bolts of fastening of the EGR valve (model of 3.0 l)

19

Bolts of fastening of the sensor of atmospheric pressure (l models 2.0 and 2.5)

6.4

Bolts of a basic arm of the sensor of atmospheric pressure (l models 2.0 and 2.5)

  • The top
6.4
  • Nizhny Novgorod
16

Bolts of fastening of the regulator of pressure of fuel (model of 3.0 l)

6.4

Bolt of fastening of the CKP sensor

6.4

Bolt of fastening of the sensor(s) of a detonation

  • L models 2.0 and 2.5
24
  • Models of 3.0 l
25

Bolt of fastening of the CMP sensor

6.4

Bolts of a basic arm of the CMP sensor (l models 2.0 and 2.5)

6.4

Sensor of temperature of cooling liquid (ECT)

16

Dokatalitichesky lambda probe(s)

21

Post-catalytic lambda probe

21